September 2020 – Caschy Van Build

Floor, Ceiling & More…

September 21, 2020June 21, 2021 caschy

Just like insulation, there are a few ways to go about finishing your van floor. The most common is probably … Read MoreFloor, Ceiling & More…

Build

All about insulation…

September 16, 2020June 21, 2021 caschy

Insulation…ah the question that gets so many varying opinions when building out a van. Foam? Wool? Denim? Pink stuff? Thinsulate? … Read MoreAll about insulation…

Build

All about storage…

September 10, 2020June 21, 2021 caschy

Before we even started with the conversion, we knew our van had to have a lot of storage. We thought … Read MoreAll about storage…

Build

All about plumbing…

September 8, 2020August 28, 2023 caschy

Since we were looking for a wet bath, we knew the plumbing would be a little bit involved. Running PEX … Read MoreAll about plumbing…

Build

All about electrical…

September 8, 2020August 28, 2023 caschy

There are so many ways to go about doing this. I chose to go with 2x 100AH Battleborn Lithium batteries … Read MoreAll about electrical…

Build

The tear up & build start…

September 8, 2020June 21, 2021 caschy

Started by removing all the seats, seat rails, floor, interior trim and rear airbags. Replaced the airbags with “simulators” (resistors) … Read MoreThe tear up & build start…

Build

The layout…

September 8, 2020June 21, 2021 caschy

The idea for the van was an RV sort of vehicle to travel out West in with our 2 kids. … Read MoreThe layout…

Build